Author Topic: Gas Dryer will not stop timer keeps going  (Read 2195 times)

Offline krazytech

  • Technician
  • Member Since: Sep 2007
  • Posts: 705
  • Country: us
    • Buy me a beer through paypal
Gas Dryer will not stop timer keeps going
« on: October 20, 2011, 10:18:10 PM »
When out on this one today;


On a ADG7005AWW gas dryer. keeps running through the cycles. When the dryer comes to the end of a cycle, the buzzer goes off, the drum continues to spin, the timer continues to run and advances to the next cycle. It goes on to the next cycle,  completes this cycle, buzzes and goes on to etc.
 Opening the door stops the dryer. Closing the door does not cause the cycle to be resumed, but using the start knob will resume .


Manually turning the timer to off will not stop the dryer..


Unplugged the (pink wire) buzzer and buzzer switch thinking they maybe shorted ... no change...


Start switch is in the timer push to start...

Timer has been changed three times and the motor has been changed also gas coils...

Any other ideas of what to check?


Timer  37001240
motor 22003776
Check the Basics first!!! Read the Manual !!!Buy the tech a Beer!!!

Offline krazytech

  • Technician
  • Member Since: Sep 2007
  • Posts: 705
  • Country: us
    • Buy me a beer through paypal
Re: Gas Dryer will not stop timer keeps going
« Reply #1 on: October 20, 2011, 10:34:27 PM »
here is the Wire Schematic  check all the wire on the timer all are marker with color codes
Check the Basics first!!! Read the Manual !!!Buy the tech a Beer!!!

Offline krazytech

  • Technician
  • Member Since: Sep 2007
  • Posts: 705
  • Country: us
    • Buy me a beer through paypal
Re: Gas Dryer will not stop timer keeps going
« Reply #2 on: October 20, 2011, 10:40:11 PM »
Ooops the model number is ADG7005AWW
Check the Basics first!!! Read the Manual !!!Buy the tech a Beer!!!

Offline Washaman

  • Technician
  • Member Since: Jul 2009
  • Posts: 494
  • Country: us
Re: Gas Dryer will not stop timer keeps going
« Reply #3 on: October 20, 2011, 11:38:37 PM »
I had an old electric Maytag in here a few years ago like that. It was the timer and I just parted it out.

Offline tgoods

  • Technician
    Moderator
  • Member Since: Jul 2010
  • Posts: 1353
  • Country: us
    • Buy me a beer through paypal
Re: Gas Dryer will not stop timer keeps going
« Reply #4 on: October 21, 2011, 12:02:52 AM »
Check your wire bundles for burnt wires and shorts.  With all the parts changing it seems like everything else is covered.

Offline JWWebster

  • Technician
  • Member Since: Jan 2008
  • Posts: 8780
  • Country: us
  • SublimeMasterJW
    • Buy me a beer through paypal
    • JW's Sublime Appliance Advice
Re: Gas Dryer will not stop timer keeps going
« Reply #5 on: October 21, 2011, 09:40:02 AM »
Contacts inside the timer are stuck together. Take it apart and free up the contacts
May the hinges of our friendship
        never grow rusty.

About the icons: The beer is tip link, if a tech saves ya some money buy em a 6 pack. The small green square=personal message. The green dot is a link to my web page on appliance repair and other general BS I love to post. The letter sends me email.
I love fan letters! LOL

Offline krazytech

  • Technician
  • Member Since: Sep 2007
  • Posts: 705
  • Country: us
    • Buy me a beer through paypal
Re: Gas Dryer will not stop timer keeps going
« Reply #6 on: October 21, 2011, 08:47:35 PM »
the timer was changed three times... I did take the 1st one apart only the push to start had a small amount of carbon,...


I can't think all three can be bad?
Check the Basics first!!! Read the Manual !!!Buy the tech a Beer!!!

Offline krazytech

  • Technician
  • Member Since: Sep 2007
  • Posts: 705
  • Country: us
    • Buy me a beer through paypal
Re: Gas Dryer will not stop timer keeps going
« Reply #7 on: October 22, 2011, 11:41:11 AM »
This one is driving me nuts. All wires look good .

Is there some way that the timer can be getting power to the timer motor from the door switch?
Check the Basics first!!! Read the Manual !!!Buy the tech a Beer!!!

Offline krazytech

  • Technician
  • Member Since: Sep 2007
  • Posts: 705
  • Country: us
    • Buy me a beer through paypal
Re: Gas Dryer will not stop timer keeps going
« Reply #8 on: October 22, 2011, 11:56:45 AM »
I was thinking
If the yellow/black wires and the black and white wires where where switched .

Yb=M
Bk/w=S

This would keep power too the timer as long as the door was closed ?
Check the Basics first!!! Read the Manual !!!Buy the tech a Beer!!!

Offline JWWebster

  • Technician
  • Member Since: Jan 2008
  • Posts: 8780
  • Country: us
  • SublimeMasterJW
    • Buy me a beer through paypal
    • JW's Sublime Appliance Advice
Re: Gas Dryer will not stop timer keeps going
« Reply #9 on: October 22, 2011, 03:40:08 PM »
The orange wire goes from the timer motor down to the 3 wire control thermostat. Obviously it runs the motor when not calling for heat. The bimetal contacts inside it must be fried together. Swap it out

http://www.appliancepartspros.com/partsearch/model.aspx?model_id=5173911&diagram_id=28596771#d28596771
May the hinges of our friendship
        never grow rusty.

About the icons: The beer is tip link, if a tech saves ya some money buy em a 6 pack. The small green square=personal message. The green dot is a link to my web page on appliance repair and other general BS I love to post. The letter sends me email.
I love fan letters! LOL

Offline krazytech

  • Technician
  • Member Since: Sep 2007
  • Posts: 705
  • Country: us
    • Buy me a beer through paypal
Re: Gas Dryer will not stop timer keeps going
« Reply #10 on: October 22, 2011, 06:21:45 PM »
thank JW


but the timer just keeps running.. if you turn the heat off it will turn off it even turns the heat off when the timer gets to offf postion but the timer keeps running to the next cycle....it points to a bad timer but with three new timer put into this machine ... I am thinking it is in the wiring...
Check the Basics first!!! Read the Manual !!!Buy the tech a Beer!!!

Offline RegUS_PatOff

  • Technician
  • Member Since: Dec 2007
  • Posts: 1410
  • Country: us
Re: Gas Dryer will not stop timer keeps going
« Reply #11 on: October 22, 2011, 08:49:39 PM »
first, check the polarity of the Wall Outlet L1 and Neutral to ground
After leaving this Earth, "Do you want the smoking or non-smoking section?"

Offline krazytech

  • Technician
  • Member Since: Sep 2007
  • Posts: 705
  • Country: us
    • Buy me a beer through paypal
Re: Gas Dryer will not stop timer keeps going
« Reply #12 on: November 01, 2011, 07:37:54 PM »
polarity was correct.,

Checked all the wires L1 was on grey... the tech before me mistook the grey power cord as a grey wire... put L1 back on yellow and it worked correctly. What you can do if you read the wire Schematic .
Check the Basics first!!! Read the Manual !!!Buy the tech a Beer!!!

Offline Washaman

  • Technician
  • Member Since: Jul 2009
  • Posts: 494
  • Country: us
Re: Gas Dryer will not stop timer keeps going
« Reply #13 on: November 01, 2011, 07:39:34 PM »
 O0

 

dryer timer does not stop at off

Started by lawncare

Replies: 3
Views: 712
Last post July 22, 2012, 05:24:56 PM
by haroldsappliance
Frigidaire Dryer Timer Knob p/n 1340354 black

Started by nivard

Replies: 6
Views: 6868
Last post March 31, 2008, 01:34:26 PM
by RegUS_PatOff
Whirpool dryer timer Part#: 691376 (needed)

Started by jet713

Replies: 4
Views: 1758
Last post April 08, 2008, 08:00:36 AM
by jet713
Dryer timer does not advance

Started by Ryan

Replies: 4
Views: 2633
Last post September 08, 2008, 01:23:39 PM
by Ryan
DE800KDW4 Timer Wiring Question - White-Westinghouse Dryer

Started by beaker

Replies: 5
Views: 2353
Last post September 19, 2008, 04:29:23 PM
by Repair-man
LG Electric Dryer Timer Problem

Started by kjustis

Replies: 1
Views: 2461
Last post December 30, 2008, 03:26:35 PM
by jumptrout51