Author Topic: Kenmore series 90 heating coil stays on when door is open  (Read 5061 times)

Offline RT1976

  • VIP Member
  • Member Since: Sep 2011
  • Posts: 12
Kenmore series 90 heating coil stays on when door is open
« on: September 01, 2011, 08:22:04 PM »
Hello,

I really need some help with my dryer... the heating coil will stay on at all times except in the off position and in the air dry cycle. Also when the timer counts down and buzzes, its not totally in the off position and the heating coil gets super hot. (this is how I realized there was a problem). If I open the door and turn the knob to the timed dry or auto dry, the coil will heat up. This is really scary, I hope you can help.

Model 110.8884293

Offline JWWebster

  • Technician
  • Member Since: Jan 2008
  • Posts: 8780
  • Country: us
  • SublimeMasterJW
    • Buy me a beer through paypal
    • JW's Sublime Appliance Advice
Re: Kenmore series 90 heating coil stays on when door is open
« Reply #1 on: September 02, 2011, 08:00:00 AM »
Heating element shorted to the frame is what it sounds like to me. What is this one of them compact dryers?
May the hinges of our friendship
        never grow rusty.

About the icons: The beer is tip link, if a tech saves ya some money buy em a 6 pack. The small green square=personal message. The green dot is a link to my web page on appliance repair and other general BS I love to post. The letter sends me email.
I love fan letters! LOL

Offline RT1976

  • VIP Member
  • Member Since: Sep 2011
  • Posts: 12
Re: Kenmore series 90 heating coil stays on when door is open
« Reply #2 on: September 02, 2011, 10:27:54 AM »
No, its a full size dryer. I think the problem started when my wife asked me to get a power cord that had fallen behind the dryer. I pulled the dryer out to get in and noticed that the exhaust was quite long. I think when I pushed it back in I squeezed the exhaust so it was pumping the warm moist air back into the dryer. Clothes were taking a lot longer to dry and when I checked on it after the dryer shut off I noticed the top of the dryer was crazy hot. I'm thinking I will take the dryer outside, open and up and give it a good clean as well. Where can I look to see if the heating element is shorted to the frame?
Thanks for the reply!
RT

Offline JWWebster

  • Technician
  • Member Since: Jan 2008
  • Posts: 8780
  • Country: us
  • SublimeMasterJW
    • Buy me a beer through paypal
    • JW's Sublime Appliance Advice
Re: Kenmore series 90 heating coil stays on when door is open
« Reply #3 on: September 02, 2011, 11:02:09 AM »
Does the filter pull out the top on your Kenmore dryer or out the door? I cannot make the model number work.
May the hinges of our friendship
        never grow rusty.

About the icons: The beer is tip link, if a tech saves ya some money buy em a 6 pack. The small green square=personal message. The green dot is a link to my web page on appliance repair and other general BS I love to post. The letter sends me email.
I love fan letters! LOL

Offline RT1976

  • VIP Member
  • Member Since: Sep 2011
  • Posts: 12
Re: Kenmore series 90 heating coil stays on when door is open
« Reply #4 on: September 02, 2011, 11:06:20 AM »
Do you mean the lint filter? if so it pulls out the top. I am at work right now so I can't take a picture sorry  :(  Filter would be at the top right hand side if you are standing in front of it.

Offline RT1976

  • VIP Member
  • Member Since: Sep 2011
  • Posts: 12
Re: Kenmore series 90 heating coil stays on when door is open
« Reply #5 on: September 02, 2011, 11:12:09 AM »
Here is pic of it that I found on google images. hope it helps.
RT

Offline JWWebster

  • Technician
  • Member Since: Jan 2008
  • Posts: 8780
  • Country: us
  • SublimeMasterJW
    • Buy me a beer through paypal
    • JW's Sublime Appliance Advice
Re: Kenmore series 90 heating coil stays on when door is open
« Reply #6 on: September 02, 2011, 12:31:03 PM »
The heater coil is on the backside. It is held by 2 screws (quarter inch hexhead) Remove it and ohm it out. It probably is shorted out. Recently I did a tune up on a Roper dryer very similar to yours Dryer revamp
Click picture to enlarge
« Last Edit: September 02, 2011, 12:32:41 PM by JWWebster »
May the hinges of our friendship
        never grow rusty.

About the icons: The beer is tip link, if a tech saves ya some money buy em a 6 pack. The small green square=personal message. The green dot is a link to my web page on appliance repair and other general BS I love to post. The letter sends me email.
I love fan letters! LOL

Offline RT1976

  • VIP Member
  • Member Since: Sep 2011
  • Posts: 12
Re: Kenmore series 90 heating coil stays on when door is open
« Reply #7 on: September 02, 2011, 12:52:07 PM »
Thanks JW O0

I hope it is as simple as that. Will update when I get home and take the sucker apart!
Cheers :cheers:
RT

Offline JWWebster

  • Technician
  • Member Since: Jan 2008
  • Posts: 8780
  • Country: us
  • SublimeMasterJW
    • Buy me a beer through paypal
    • JW's Sublime Appliance Advice
Re: Kenmore series 90 heating coil stays on when door is open
« Reply #8 on: September 02, 2011, 01:25:26 PM »
Let us know how it goes.
May the hinges of our friendship
        never grow rusty.

About the icons: The beer is tip link, if a tech saves ya some money buy em a 6 pack. The small green square=personal message. The green dot is a link to my web page on appliance repair and other general BS I love to post. The letter sends me email.
I love fan letters! LOL

Offline RT1976

  • VIP Member
  • Member Since: Sep 2011
  • Posts: 12
Re: Kenmore series 90 heating coil stays on when door is open
« Reply #9 on: September 03, 2011, 01:33:16 PM »
Ok, took it apart. Tested the heater coil, and the wires going to the heater. Got a signal (beep) after testing each one. I'm a noob so I hope I understood you properly. Nothing looks broken or fried.
Thanks, RT

Offline JWWebster

  • Technician
  • Member Since: Jan 2008
  • Posts: 8780
  • Country: us
  • SublimeMasterJW
    • Buy me a beer through paypal
    • JW's Sublime Appliance Advice
Re: Kenmore series 90 heating coil stays on when door is open
« Reply #10 on: September 03, 2011, 01:47:24 PM »
Do you get a beep between either terminal to the heater housing?

May the hinges of our friendship
        never grow rusty.

About the icons: The beer is tip link, if a tech saves ya some money buy em a 6 pack. The small green square=personal message. The green dot is a link to my web page on appliance repair and other general BS I love to post. The letter sends me email.
I love fan letters! LOL

Offline RT1976

  • VIP Member
  • Member Since: Sep 2011
  • Posts: 12
Re: Kenmore series 90 heating coil stays on when door is open
« Reply #11 on: September 03, 2011, 02:14:30 PM »
Decided to run it again after a thorough cleaning of the terminals and looks like its working again!  O0
Shuts off when I open the door and doesn't come on if it's not totally on the off position. I blew a lot of dust out of that housing on the heater coil. I'm thinking you were right about it shorting to the frame.
Thanks for your help JW

RT

Offline RT1976

  • VIP Member
  • Member Since: Sep 2011
  • Posts: 12
Re: Kenmore series 90 heating coil stays on when door is open
« Reply #12 on: September 03, 2011, 02:58:14 PM »
Ok, problem not solved. if the housing is touching the frame it will still power on when it shouldn't. When I tested it earlier it was off the frame on the ground. aarrrgh!

Offline RT1976

  • VIP Member
  • Member Since: Sep 2011
  • Posts: 12
Re: Kenmore series 90 heating coil stays on when door is open
« Reply #13 on: September 03, 2011, 03:00:27 PM »
And yes I get a beep (not as loud) when I touch either terminal + the housing

Offline JWWebster

  • Technician
  • Member Since: Jan 2008
  • Posts: 8780
  • Country: us
  • SublimeMasterJW
    • Buy me a beer through paypal
    • JW's Sublime Appliance Advice
Re: Kenmore series 90 heating coil stays on when door is open
« Reply #14 on: September 03, 2011, 06:09:24 PM »
Get a new heater and party on!
Do an autopsy, take the heater from the dryer and remove the coils from the housing.
They sell the element only a little cheaper you reuse the heavy metal heater housing.
Its a hastle but ya save 5 bucks.
« Last Edit: September 03, 2011, 06:11:33 PM by JWWebster »
May the hinges of our friendship
        never grow rusty.

About the icons: The beer is tip link, if a tech saves ya some money buy em a 6 pack. The small green square=personal message. The green dot is a link to my web page on appliance repair and other general BS I love to post. The letter sends me email.
I love fan letters! LOL

 

Kenmore 90 series heating element stays on.

Started by AnnesLimo

Replies: 63
Views: 7279
Last post February 18, 2012, 09:42:43 PM
by tgoods
Kenmore 80 dryer will not stop if i open the door..

Started by mikedee5

Replies: 2
Views: 1817
Last post June 29, 2009, 10:59:41 AM
by AJ
Kenmore 110.67732791 heating element stays on

Started by bladeguy08

Replies: 16
Views: 2810
Last post February 15, 2012, 07:09:52 PM
by AJ
Kenmore dryer door won't shut!

Started by krisncameron

Replies: 8
Views: 15200
Last post April 29, 2011, 08:21:47 PM
by evesnlm
Kenmore 70 series Elecric Dryer...cuts off

Started by lalakelley

Replies: 12
Views: 5710
Last post February 20, 2008, 12:07:10 PM
by AJ
Kenmore 70 series electric dryer...wont heat

Started by lalakelley

Replies: 53
Views: 37344
Last post November 24, 2011, 02:40:03 AM
by RegUS_PatOff