Author Topic: Dishwasher slow leak  (Read 5867 times)

Offline prime311

  • VIP Member
  • Member Since: Sep 2010
  • Posts: 26
Dishwasher slow leak
« on: September 25, 2010, 10:58:15 PM »
I have a Whirpool Quiet Partner II Imperial, model number DUL200PKB1.  Pardon my poor description here as I am no expert on dishwashers by any means, but would like to fix this on my own if I can.  There is a slow leak coming from the dishwasher when it runs.  I took front bottom plate off and reattached all the hoses as well as a 6 inch or so long hard plastic tube that was screwed into the motor area and attached to either the drain or hot water.  It still leaked, so I screwed that plastic tube in again this time with plumbers tape, but again to no avail.  The leak occurs at what appears to be a specific time.  After i turn the dishwasher on I can hear water running into the dishwasher, then that turns off and it does a lurch.  Not physically moving, but its clearly changing into a different cycle at that point, maybe starting to wash?  Well at that point, I can feel water spray out underneath the dishwasher, for a split second and then it stops.  Then it will spray out water again at different times during the run.  It is not a large leak as I currently have a cookie sheet down there and a full run only makes a millimeter or so of standing water.  If anyone has any idea as to what might be leaking based on that description I'd appreciate any help.  I did find another link that talked about replacing the lower motor seal on a similar washer and I thought that looked doable.  I didnt have broken dishes, but the steps they did sound like the ones i tried as well.  

This is that other link: http://appliancejunk.com/forums/index.php?topic=3021.0


Thanks!
Spence    

Offline tgoods

  • Technician
    Moderator
  • Member Since: Jul 2010
  • Posts: 1526
  • Country: us
    • Buy me a beer through paypal
Re: Dishwasher slow leak
« Reply #1 on: September 26, 2010, 01:19:19 AM »
Tighten the pump cover screws.  If the pump cover seal has blown out, replace it.  Part number 302711

Offline mattlwil

  • VIP Member
  • Member Since: Sep 2010
  • Posts: 22
    • Appliance Repair Memphis TN
Re: Dishwasher slow leak
« Reply #2 on: September 27, 2010, 12:37:04 PM »
Check drain hose for a pin hole leak.

Offline prime311

  • VIP Member
  • Member Since: Sep 2010
  • Posts: 26
Re: Dishwasher slow leak
« Reply #3 on: September 27, 2010, 11:19:24 PM »
Tighten the pump cover screws.  If the pump cover seal has blown out, replace it.  Part number 302711

So far so good.  I tried tightening the star screws with a normal driver, but they were fairly tight so I switched to a ratchet and was able to get another half turn or so on each.  Ran it once and watched it close for 20 minutes or so.  At one point i did feel a very slight spray of water.  Let it finish.  Still dry.  Put it all back in place and ran it another full time and still dry.  So thats a huge improvement.  I still might need to replace the seal cause I did feel that one slight mist, but i dont see any water at all!  I must say kudos to whirlpool too this motor has a ton of gunk and water leavings on it and it still runs like a champ.  Thanks so much for the help as that definitely was the issue.  Going to monitor it for a week or 2 and put the front back in if its all dry or replace the seal if its not. 

Offline prime311

  • VIP Member
  • Member Since: Sep 2010
  • Posts: 26
Re: Dishwasher slow leak
« Reply #4 on: October 02, 2010, 07:49:03 PM »
Well after a week of use its leaking a little more again, although not as much as originally.  I'm going to order and replace the seal ring.  I did have one question though.  I was going to orderthis bearing ring well since I thought it was broken, but I see the ring pictured as not completely closed.  Probably a dumb question since its pictured that way, but that is the way its supposed to be(not a closed circle)?   

Offline prime311

  • VIP Member
  • Member Since: Sep 2010
  • Posts: 26
Re: Dishwasher slow leak
« Reply #5 on: October 02, 2010, 07:51:36 PM »
Actually scratch that last question, I found more pictures showing the same thing.  I'll update you when I get the seal replaced.  Thanks again!

Offline JWWebster

  • Technician
  • Member Since: Jan 2008
  • Posts: 8781
  • Country: us
  • SublimeMasterJW
    • Buy me a beer through paypal
    • JW's Sublime Appliance Advice
Re: Dishwasher slow leak
« Reply #6 on: October 02, 2010, 09:01:07 PM »
Are you using liquid dish washing liquid? That would make it leak.
May the hinges of our friendship
        never grow rusty.

About the icons: The beer is tip link, if a tech saves ya some money buy em a 6 pack. The small green square=personal message. The green dot is a link to my web page on appliance repair and other general BS I love to post. The letter sends me email.
I love fan letters! LOL

Offline prime311

  • VIP Member
  • Member Since: Sep 2010
  • Posts: 26
Re: Dishwasher slow leak
« Reply #7 on: October 03, 2010, 12:35:06 AM »
You cant be serious?  I use those plastic packets that have liquid and detergent in like these.

Offline schaffersapplian

  • Technician
  • Member Since: Oct 2008
  • Posts: 619
  • Country: us
  • Every action has a reaction
    • Facebook
Re: Dishwasher slow leak
« Reply #8 on: October 03, 2010, 06:47:01 AM »
Yea prime, Just check the machine for suds.  Its a very common reason for dishwashers to leak.  It only takes a drop of regular dish soap to create suds inside the tank.  Turn your dishwasher on, let it agitate for a few minutes, then open the door.  There should be NO suds inside.  If you find suds, take any kind of cooking oil and splash it into the suds.  The oil will remove the suds.  Instant coffee creamer works as well.
Authorized Samsung, Electrolux, Whirlpool, GE, Fisher Paykal, and Maytag Servicer with over 10 years experience.

Offline JWWebster

  • Technician
  • Member Since: Jan 2008
  • Posts: 8781
  • Country: us
  • SublimeMasterJW
    • Buy me a beer through paypal
    • JW's Sublime Appliance Advice
Re: Dishwasher slow leak
« Reply #9 on: October 03, 2010, 12:26:32 PM »
Switch to the cascade powder stuff thats been around for years.
May the hinges of our friendship
        never grow rusty.

About the icons: The beer is tip link, if a tech saves ya some money buy em a 6 pack. The small green square=personal message. The green dot is a link to my web page on appliance repair and other general BS I love to post. The letter sends me email.
I love fan letters! LOL

 

Whirlpool Dishwasher Model GU940SCGB3 Door Leak

Started by JimKaran

Replies: 10
Views: 13865
Last post September 13, 2007, 11:39:39 AM
by AJ
Video: Whirlpool Dishwasher Door Leak - How to replace pump seal.

Started by AJ

Replies: 0
Views: 8148
Last post September 13, 2007, 06:45:17 PM
by AJ
when your LG dishwasher starts to leak read this

Started by BrntToast

Replies: 1
Views: 8886
Last post December 31, 2007, 06:48:29 PM
by AJ
Dishwasher door leak

Started by bud6161

Replies: 3
Views: 3362
Last post December 16, 2008, 05:28:48 AM
by Repair-man
LG dishwasher leak, AGAIN

Started by cnorth06

Replies: 3
Views: 2393
Last post September 25, 2009, 10:34:34 AM
by JWWebster
Whirlpool Dishwasher Slow Water Inlet

Started by mdfudge

Replies: 7
Views: 4988
Last post October 02, 2010, 11:42:26 AM
by JWWebster