Author Topic: Water leaks thru door  (Read 3225 times)

Offline tlplumco

  • VIP Member
  • Member Since: Aug 2009
  • Posts: 5
Water leaks thru door
« on: August 08, 2009, 08:24:38 AM »
My front load LG WM2277HB washer leaks water thru the door on the recirculation water cycle diagnostic #10 troubleshoot process. I checked the gasket and door and there is no visible signs of any debris buildup or tears on the gasket. The door lock is working properly and I removed the front panel to check inside. This washer is 6 years old.
Any HELP would be appreciated.
TY

Offline RegUS_PatOff

  • Technician
  • Member Since: Dec 2007
  • Posts: 1410
  • Country: us
Re: Water leaks thru door
« Reply #1 on: August 08, 2009, 08:03:37 PM »
Is the Water Level that high that it actually touches the Door Seal / Glass ?
After leaving this Earth, "Do you want the smoking or non-smoking section?"

Offline tlplumco

  • VIP Member
  • Member Since: Aug 2009
  • Posts: 5
Re: Water leaks thru door
« Reply #2 on: August 09, 2009, 09:13:28 AM »
Hello,
No, it happens when the recirculation pump goes on and the nozzle at the top of the door pours water down the glass from the top.
Then it pours out from the bottom of the door.
Tom

Offline PARTech

  • Technician
  • Member Since: May 2009
  • Posts: 415
  • Country: us
    • Buy me a beer through paypal
    • Panhandle Appliance LLC
Re: Water leaks thru door
« Reply #3 on: August 09, 2009, 09:15:57 AM »
As unlikley as it seems, from your description the door/gasket connection is where it is coming from.  Clean the inner glass where it touches the door and inspect the gasket (by feel).  You can pull the spring clamp off the gasket and inspect the recirc hose connection at the top, but it comes off easier than it goes on, a cotter pin puller or other hook tool works wonders for hooking the FRONT spring back on.
Serving North Idaho

Offline tlplumco

  • VIP Member
  • Member Since: Aug 2009
  • Posts: 5
Re: Water leaks thru door
« Reply #4 on: August 09, 2009, 09:39:30 AM »
I cleaned the glass and pulled the front panel off to inspect the gasket and it seems to be fine.I did not pull the spring clamp on the front because of the rust buildup on the spring.
I was wondering if the rust on the front spring clamp might have something to do with it?

Offline PARTech

  • Technician
  • Member Since: May 2009
  • Posts: 415
  • Country: us
    • Buy me a beer through paypal
    • Panhandle Appliance LLC
Re: Water leaks thru door
« Reply #5 on: August 09, 2009, 09:41:26 AM »
One other fix, if everything is clean I have used a washer between the door latch and the front panel to tighten the door. You can do that through the gasket on the front as well.  Just put a washer on each screw. Fine needlenose plyers help. :) And yes the rust could cause it to swell and not make a good seal.
Serving North Idaho

Offline tlplumco

  • VIP Member
  • Member Since: Aug 2009
  • Posts: 5
Re: Water leaks thru door
« Reply #6 on: August 09, 2009, 09:45:35 AM »
Let me give that a try and I'll let you know the results.
TY

 

Water Leaks From the Door When Washer is Running

Started by Bowhunter

Replies: 2
Views: 1474
Last post March 01, 2009, 12:27:09 PM
by JWWebster
samsung washer front door leaks

Started by gabriord

Replies: 4
Views: 5028
Last post October 06, 2011, 04:55:40 PM
by Canuckistan
washer----leaks at water inlet valve

Started by yabadabadoo1026

Replies: 3
Views: 2418
Last post January 26, 2008, 04:45:11 PM
by RegUS_PatOff
Maytag Dependable Drive Washer - Leaks Water

Started by AJ

Replies: 1
Views: 6081
Last post May 30, 2008, 05:41:48 AM
by Repair-man
duet leaks out door during clean

Started by BrntToast

Replies: 3
Views: 1432
Last post May 14, 2009, 05:20:00 PM
by jayman73
Washer leaks water

Started by Gary O

Replies: 4
Views: 1734
Last post November 13, 2009, 06:44:07 AM
by Repair-man