Author Topic: Contactor 101  (Read 2716 times)

Offline JWWebster

  • Technician
  • Member Since: Jan 2008
  • Posts: 8780
  • Country: us
  • SublimeMasterJW
    • Buy me a beer through paypal
    • JW's Sublime Appliance Advice
Contactor 101
« on: April 29, 2009, 10:59:02 PM »
Magnetic relays commonly known as definite purpose contactors are used in a variety of different applications throughout the HVAC and Appliance world. They can have anywhere  from 1 pole or up to 4 poles or more. The coils on them can be 24 volt 120 volt 240 volt or even 440 volt and better. Their main job is to power compressors and fan motors on various equipment. On a home unit the contactor is almost always a 24 volt 2 pole 30 amp one. Some smaller units have what is known as a pole and a half. or 1.5 poles. The coil pulls down only one side of the contactor, while the common leg has a straight bar across it. On home units smaller thermostat wires connect to the 24 volt coil. When the temp rises the thermostat calls for the contactor to yank down and power up the compressor and fan outside. if those small wires are chewed up by an animal or a weed eater then power to the coil cannot
do its job. Sometimes the coil simply dies like a light bulb. If the coil is open then nothing will happen when the thermostat calls for cooling. Sometimes the contacts on the contactor get burned and fall apart. The coil yanks down the contacts fine but sadly the points are fried. Sometimes a critter will make a home right under the contacts. When the weather turns warm the coil yanks down and you have crispy critter and no cooling either. Oh the inside will work but nothing will happen outside until the contactor is replaced. 240 volts will kill you. Make sure to kill the power to outside unit before servicing any part.
« Last Edit: April 29, 2009, 11:00:33 PM by JWWebster »
May the hinges of our friendship
        never grow rusty.

About the icons: The beer is tip link, if a tech saves ya some money buy em a 6 pack. The small green square=personal message. The green dot is a link to my web page on appliance repair and other general BS I love to post. The letter sends me email.
I love fan letters! LOL

Offline Icehouse

  • Technician
  • Member Since: Oct 2008
  • Posts: 566
    • hvacbob
Re: Contactor 101
« Reply #1 on: May 01, 2009, 06:05:16 AM »
Not trying to steal your show JW, but:

On most single-phase compressors with a single-pole contactor, there is a solid bar on one side of the contactor instead of having two contacts. One leg of power passes down the bar to the capacitor and to the run winding. It passes through the run winding of the compressor and from common back to the contactor. It lands on the load side of the normally open contact of the contactor. At off cycle, line voltage will be read from one side of the normally open contact to the other: Line 1 on the line side and Line 2 on the load side via the windings.
The crankcase heater will be attached to the contactor with one leg on the load side and one on the line side of the normally open contacts. At off cycle it will have line voltage applied to it and will heat the crankcase. Once the contactor is energized, both the line and load side of the normally open contacts become one. Since you cannot feed a load with one line of power, the crankcase heater will not work again until the contactor opens. This is a simple way to turn the crankcase heater off during the on cycle and to turn it on at the off cycle. Exercise caution when checking this type of setup because power is always present on the load side of the contactor.

NATE, NCCER, PHCC,HVAC Certified Instructor
Member RSES, US Army Refrigeration Specialist(Retired), Former Refrigeration Teacher NYC Board of Ed.
a tragedy has happen to me : http://web.me.com/zenzoidman/Bobice/

Offline JWWebster

  • Technician
  • Member Since: Jan 2008
  • Posts: 8780
  • Country: us
  • SublimeMasterJW
    • Buy me a beer through paypal
    • JW's Sublime Appliance Advice
Re: Contactor 101
« Reply #2 on: May 01, 2009, 01:41:19 PM »
Nice post Bobby. I might get ya to be a contributing editor to my world class cheap ass Sublime appliance repair google site.
May the hinges of our friendship
        never grow rusty.

About the icons: The beer is tip link, if a tech saves ya some money buy em a 6 pack. The small green square=personal message. The green dot is a link to my web page on appliance repair and other general BS I love to post. The letter sends me email.
I love fan letters! LOL

Offline Icehouse

  • Technician
  • Member Since: Oct 2008
  • Posts: 566
    • hvacbob
Re: Contactor 101
« Reply #3 on: May 01, 2009, 03:07:17 PM »
 O0 O0 :) Thanks but between AJ,Jake,Scotty and on the "Educational Committee" for hvac-talk.com my bill is full.
NATE, NCCER, PHCC,HVAC Certified Instructor
Member RSES, US Army Refrigeration Specialist(Retired), Former Refrigeration Teacher NYC Board of Ed.
a tragedy has happen to me : http://web.me.com/zenzoidman/Bobice/

Offline shieldcracker

  • VIP Member
  • Member Since: Nov 2008
  • Posts: 86
Re: Contactor 101
« Reply #4 on: May 02, 2009, 06:32:32 PM »
Very nice AJ, did you really write this?  ::)

Offline AJ

  • Technician
    Administrator
  • Member Since: Jun 2007
  • Posts: 9225
  • Country: us
    • ApplianceJunk.com - Appliance Repair Help
Re: Contactor 101
« Reply #5 on: May 02, 2009, 06:36:20 PM »
Very nice AJ, did you really write this?  ::)

This is my first post in this topic so I did not write any of it. :)
Hope you find our site helpful.

Offline Icehouse

  • Technician
  • Member Since: Oct 2008
  • Posts: 566
    • hvacbob
Re: Contactor 101
« Reply #6 on: May 02, 2009, 09:54:49 PM »
Very nice AJ, did you really write this?  ::)
Cough,cough  :) I wrote it.
NATE, NCCER, PHCC,HVAC Certified Instructor
Member RSES, US Army Refrigeration Specialist(Retired), Former Refrigeration Teacher NYC Board of Ed.
a tragedy has happen to me : http://web.me.com/zenzoidman/Bobice/

Offline shieldcracker

  • VIP Member
  • Member Since: Nov 2008
  • Posts: 86
Re: Contactor 101
« Reply #7 on: May 03, 2009, 10:01:30 AM »
Excuse my dyslexia, stuff happens from time to time.