Author Topic: Replace Gas Furnace and Possibly Air Central Air  (Read 3155 times)

Offline hleebeard@sbcglo

  • VIP Member
  • Member Since: Jan 2009
  • Posts: 24
Replace Gas Furnace and Possibly Air Central Air
« on: April 05, 2009, 03:09:21 PM »
I have two Natural Gas fired furnaces, each with a central Air Unit with compressor outside.   They are both down flow with the heating ducts under the slab and the return air through the attic. One is 125k btu furnace in the garage utility closet with a 3.6 ton air and the other is a 75,000 btu in an inside hall closet with 2.5 central air unit with compressor outside.  They are 25 years old and one is giving some problems.   It may have a cracked heat exchanger and or a defective thermocouple.  There is some yellow tips on the flame and the pilot light is frequently goes out.  I would like to replace these units myself.    I live in Oklahoma where ac is more important than heating, although it gets moderately cold here in the winter.

I would like to buy a couple of higher efficiency units that would not require extensive plennum work versus the ones that I have now.  In 1971 I installed a 2 ton central air in my first little house.  The lines, condensing unit and evaporator were precharged and it was a fairly easy installation into an existing forced air furnace in my basement.

Do you know if I can still get this kind of kit and is it still legal to install my own heating and cooling system?   What is a good and available brand and an economical source for it?

UGLA-125A-CR

Offline JWWebster

  • Technician
  • Member Since: Jan 2008
  • Posts: 8780
  • Country: us
  • SublimeMasterJW
    • Buy me a beer through paypal
    • JW's Sublime Appliance Advice
Re: Replace Gas Furnace and Possibly Air Central Air
« Reply #1 on: April 05, 2009, 05:01:55 PM »
These newer model heat pumps drop your power bill by half or better.
May the hinges of our friendship
        never grow rusty.

About the icons: The beer is tip link, if a tech saves ya some money buy em a 6 pack. The small green square=personal message. The green dot is a link to my web page on appliance repair and other general BS I love to post. The letter sends me email.
I love fan letters! LOL

Offline Repair-man

  • Technician
  • Member Since: Feb 2008
  • Posts: 3020
  • Country: us
  • The Virtual Repairman
    • The Virtual Repairmans Appliance Help
Re: Replace Gas Furnace and Possibly Air Central Air
« Reply #2 on: April 05, 2009, 10:35:34 PM »
I have a downflow gas furnace in my place as well, made by Intertherm. They are the leader in downflow technology.  Check out some of their products:

Intertherm

And no, it's not illegal to do your own A/C work in most states, it's just difficult finding a distributor to sell to an unlicensed person.
« Last Edit: April 06, 2009, 07:55:17 AM by Repair-man »
"It's only expensive if someone else fixes it for you" -
The Virtual Repairman   www.repair2000.com

Offline jumptrout51

  • Technician
  • Member Since: Nov 2007
  • Posts: 1879
  • Country: us
    • Buy me a beer through paypal
Re: Replace Gas Furnace and Possibly Air Central Air
« Reply #3 on: April 06, 2009, 12:36:11 PM »
You can buy central systems online all day long for less than I pay for them wholesale at my supply houses. But, then they do add a shipping cost.
The supply houses in my area will not honor warranty on internet equipment purchases.
I believe Intertherm sells the pre-charged self tapping systems.
Take a Kid fishing.

 

Replace or repair lennox gas furnace G26Q3-75

Started by teepee9

Replies: 0
Views: 3508
Last post October 17, 2009, 10:52:28 AM
by teepee9
Airtemp furnace

Started by maypo52

Replies: 9
Views: 8991
Last post March 05, 2008, 02:36:32 PM
by JWWebster
whirpool furnace fs643-125cr

Started by ddh

Replies: 2
Views: 3213
Last post July 04, 2008, 09:44:24 AM
by ddh
central air unit line freezing

Started by plan1

Replies: 3
Views: 4868
Last post October 23, 2008, 09:27:20 PM
by Icehouse
Rheem Furnace needs a new Thermo Coupler

Started by rezman6

Replies: 3
Views: 6694
Last post October 31, 2008, 08:07:56 AM
by Icehouse
Furnace fan keeps running after normal shutoff by thermostat.

Started by hleebeard@sbcglo

Replies: 1
Views: 6581
Last post January 10, 2009, 09:00:48 PM
by JWWebster