Author Topic: MI40TSLN10 Bradford White natural gas Hotwater heater  (Read 2905 times)

Offline neustkg

  • VIP Member
  • Member Since: Dec 2008
  • Posts: 31
MI40TSLN10 Bradford White natural gas Hotwater heater
« on: March 23, 2009, 11:53:31 AM »
I have the above hot water heater.  I'm pretty sure it is the original water heater that was installed in our home when it was built in 1994.  I also would assume the previous owners (including myself since 2005) never drained it yearly to reduce the sediment.  There is a label on the heater that says it has Hydrojet technology, which means it may have an internal fan that churns the sediment and drains it (although I've never ever noticed it draining into the drain in the basement)--who knows, maybe that feature no longer works as it is probably 15 years old now.  I do notice less hot water in reserve these days, so I am assuming it is definitely filling up w/sediment, reducing the volume from 40 gallons to who knows.  

My question is this:  Even though the tank is probably 15 years old and probably never has been drained to reduce sediment, is it OK to do it now?  It is a natural gas unit, one person told me it is safe to do so as there should be nothing inside to damage.  Another person told me that draining it would do no good as a lot of the old hot water heaters had plastic dip tubes that slowly dissolved over time as the sediment layer rises.

So, can I drain it, or should I just up the temp for a while until the sediment rises to the top and I pretty much have no hot water in reserve (and then buy a new hot water heater)?

Offline Repair-man

  • Technician
  • Member Since: Feb 2008
  • Posts: 3020
  • Country: us
  • The Virtual Repairman
    • The Virtual Repairmans Appliance Help
Re: Bradford White natural gas Hotwater heater
« Reply #1 on: March 23, 2009, 12:43:59 PM »
Draining it is always a good idea, every year. You may not be able to get all the trash out of it, but it certainly shouldn't hurt. The "Hydro-Swirl" feature is nothing more than a circular dip tube that swooshes the water wround as it enters the tank. No circulating pump or anything else.


Set your thermostat back to the Pilot position during the drainout. I usually hook up a hose and open the bottom valve while the pressure is still up, which causes more sediment to flush out than if water to the unit was shut down. It takes approx. 20 minutes to fush it good. If the unit is inside the house, simply run the hose to any toilet or bathtub.
« Last Edit: March 23, 2009, 12:46:29 PM by Repair-man »
"It's only expensive if someone else fixes it for you" -
The Virtual Repairman   www.repair2000.com

Offline neustkg

  • VIP Member
  • Member Since: Dec 2008
  • Posts: 31
Re: Bradford White natural gas Hotwater heater
« Reply #2 on: March 23, 2009, 12:56:55 PM »
I'm lucky that I have a drain about 2 feet from the drain of the hot water heater.

Do you think I might cause the heater to die early by draining it?

Offline Icehouse

  • Technician
  • Member Since: Oct 2008
  • Posts: 566
    • hvacbob
NATE, NCCER, PHCC,HVAC Certified Instructor
Member RSES, US Army Refrigeration Specialist(Retired), Former Refrigeration Teacher NYC Board of Ed.
a tragedy has happen to me : http://web.me.com/zenzoidman/Bobice/

 

How often do you replace your water heater?

Started by frankster

Replies: 20
Views: 10751
Last post March 02, 2013, 07:45:21 PM
by bigbuck
whirlpool hot water heater

Started by bigjon30

Replies: 1
Views: 1928
Last post October 19, 2009, 05:58:51 PM
by JWWebster
Hot Water Heater went Nuts!

Started by slim

Replies: 4
Views: 2956
Last post November 02, 2009, 05:47:36 PM
by jumptrout51
Water Heater Fix -- little hot water -- fixed with inlet tube.

Started by sapp4l

Replies: 1
Views: 2239
Last post December 13, 2009, 05:08:45 PM
by JWWebster
The water heater of the future

Started by JWWebster

Replies: 0
Views: 2044
Last post December 28, 2009, 07:10:38 PM
by JWWebster
whirlpool hot water heater

Started by abhersh64

Replies: 6
Views: 4915
Last post February 03, 2010, 06:47:00 AM
by Repair-man