Author Topic: Maytag gas dryer won't heat up unless bottom front panel is removed  (Read 7923 times)

Offline ah3000bj8

  • VIP Member
  • Member Since: Jan 2009
  • Posts: 8
Hello, I have a Maytag gas dryer model SDG3606AWG. It wasn't heating up very well. Took a long time to dry and the timer wasn't advancing on any setting. The top of the dryer was barely above room temp. I put in a new cycling thermostat and still the same problem. When I took the bottom front panel off to check out the burner, it was lit. I watched it a while and it seemed to work fine. I then noticed that the top of the dryer was warm like it should be. I let it go and it worked fine for several loads. Put the bottom panel back on and it won't dry again. Take the panel off and it works good. Help! Thanks in advance.

Offline Repair-man

  • Technician
  • Member Since: Feb 2008
  • Posts: 3020
  • Country: us
  • The Virtual Repairman
    • The Virtual Repairmans Appliance Help
Re: Maytag gas dryer won't heat up unless bottom front panel is removed
« Reply #1 on: January 13, 2009, 06:55:12 PM »
Take the vent off the back and see what happens.
"It's only expensive if someone else fixes it for you" -
The Virtual Repairman   www.repair2000.com

Offline ah3000bj8

  • VIP Member
  • Member Since: Jan 2009
  • Posts: 8
Re: Maytag gas dryer won't heat up unless bottom front panel is removed
« Reply #2 on: January 13, 2009, 07:00:32 PM »
Sorry, I should have mentioned that I did that and still had the same problem. I also cleaned made sure the lint filter passage was very clean. And I checked the blower fan - it was good too.

Offline jumptrout51

  • Technician
  • Member Since: Nov 2007
  • Posts: 1879
  • Country: us
    • Buy me a beer through paypal
Re: Maytag gas dryer won't heat up unless bottom front panel is removed
« Reply #3 on: January 13, 2009, 07:06:45 PM »
Repair-man is correct.
You have a airflow problem somewhere.
Your fresh air makeup changes when you open the inspection cover and it works OK.
If not the exhaust vent, then incoming air is blocked or not circulating.
Take a Kid fishing.

Offline ah3000bj8

  • VIP Member
  • Member Since: Jan 2009
  • Posts: 8
Re: Maytag gas dryer won't heat up unless bottom front panel is removed
« Reply #4 on: January 13, 2009, 07:14:07 PM »
It works ok with the exhaust vent hooked up and just the front panel removed. So, you'd think it was an incoming air restriction, right? Where does it get the incoming air? Is there an inlet somewhere?

Offline Repair-man

  • Technician
  • Member Since: Feb 2008
  • Posts: 3020
  • Country: us
  • The Virtual Repairman
    • The Virtual Repairmans Appliance Help
Re: Maytag gas dryer won't heat up unless bottom front panel is removed
« Reply #5 on: January 13, 2009, 07:23:43 PM »
What we do is set a thermometer in the vent outlet in back and run the dryer normally (no vent attached). If it maintains 145-155 degrees, the dryer is OK.

The drum seals must be intact to form a good combustion environment for the gas burners, otherwise it will cycle off on hi-limit. Be sure you inspected the entire blower housing with the front panel removed.

and no, I do not think it is an incoming air issue ...
« Last Edit: January 13, 2009, 07:25:36 PM by Repair-man »
"It's only expensive if someone else fixes it for you" -
The Virtual Repairman   www.repair2000.com

Offline ah3000bj8

  • VIP Member
  • Member Since: Jan 2009
  • Posts: 8
Re: Maytag gas dryer won't heat up unless bottom front panel is removed
« Reply #6 on: January 14, 2009, 05:58:19 AM »
Thanks, I'll check that out. How about if the felt seal around the lint filter element is missing - would that do it?

Offline Repair-man

  • Technician
  • Member Since: Feb 2008
  • Posts: 3020
  • Country: us
  • The Virtual Repairman
    • The Virtual Repairmans Appliance Help
Re: Maytag gas dryer won't heat up unless bottom front panel is removed
« Reply #7 on: January 14, 2009, 06:08:56 AM »
The only thing a worn filter seal would do is allow lint to escape onto the load. The entire filter housing is enclosed within the drum, so air pressure would be the same  whether the filter was in place or not.

Questions:

Has this dryer successfully run in this same location for some time?
When you chaged the thermostat on the blower housing, did you check that the seal was in place on front of the housing where it covers the fan?
« Last Edit: January 14, 2009, 06:19:49 AM by Repair-man »
"It's only expensive if someone else fixes it for you" -
The Virtual Repairman   www.repair2000.com

Offline ah3000bj8

  • VIP Member
  • Member Since: Jan 2009
  • Posts: 8
Re: Maytag gas dryer won't heat up unless bottom front panel is removed
« Reply #8 on: January 14, 2009, 12:25:26 PM »
Hello, Yes, the dryer has been in the same spot since new - at least 2 yrs. If you're talking about the sponge type seal between the front cover assembly where it mates to the fan housing, yes, that's in place and in good shape. I haven't checked the temp in the vent outlet yet, I'll do that when I get home. Should I have the front panel installed when I do that?

Offline Repair-man

  • Technician
  • Member Since: Feb 2008
  • Posts: 3020
  • Country: us
  • The Virtual Repairman
    • The Virtual Repairmans Appliance Help
Re: Maytag gas dryer won't heat up unless bottom front panel is removed
« Reply #9 on: January 14, 2009, 12:38:50 PM »
Yes
"It's only expensive if someone else fixes it for you" -
The Virtual Repairman   www.repair2000.com

 

maytag dryer model # md 3500 (no heat)

Started by #13

Replies: 5
Views: 7157
Last post December 05, 2007, 07:15:02 AM
by apptech
Maytag Dryer No Heat

Started by TechnicianBrian

Replies: 0
Views: 2376
Last post March 21, 2008, 08:25:14 PM
by TechnicianBrian
Maytag Neptune dryer has no heat

Started by Walker231T

Replies: 27
Views: 44689
Last post April 05, 2008, 08:56:36 PM
by JWWebster
Maytag dryer does not always heat

Started by hookcapn

Replies: 10
Views: 4660
Last post April 28, 2008, 03:07:15 PM
by JWWebster
16023110 Maytag Sloped Front Dryer Service Repair Manual

Started by AJ

Replies: 0
Views: 5361
Last post October 12, 2008, 12:18:00 PM
by AJ
Maytag gas dryer does not always heat

Started by hv3

Replies: 2
Views: 1542
Last post May 23, 2012, 09:37:15 AM
by JWWebster