Author Topic: GE 6 years old fridge not cooling, compressor on 24/7?  (Read 5656 times)

Offline mdm6713

  • VIP Member
  • Member Since: Jan 2009
  • Posts: 10
GE 6 years old fridge not cooling, compressor on 24/7?
« on: January 13, 2009, 12:58:30 PM »
Hello, I thought perhaps a power surge may have burnt the motherboard so I installed a Surge protector and a new motherboard however Im getting the same result. One day the ice in the Ice maker melted and there was no more cooling after that. The compressor will run steadily at what seems like a low level. Its not making a lot fo noise, but its hummings. The fan is the jelly roll is turning but no hot air, only room temp. The fan inside the fridge are blowing what seems to be slightly cooled air. The Ref. was unplugged for several days, then I put the new motherboard in. Everything looks new from the back, I dont see any apparent leak, although I didnt open it up from the inside. No frosting issues are known. The compressor will shut off when you turn the dial on the thermostat to 0. Theres no digital controls on my model, just a temp dial. It leads me to think the thermostat is good. There was a lot of water coming from the Freezer, could there be a damaged thermistor or heater thermostat from an overfrost? Where should I go with this? Any help is appreciated.  tHAnks a lot
Michael

Model GSS25VFPAWW 

Offline Mr. Fix-It

  • Technician
  • Member Since: Jan 2009
  • Posts: 357
Re: GE 6 years old fridge not cooling, compressor on 24/7?
« Reply #1 on: January 13, 2009, 01:24:29 PM »
Either a refridgerant leak (none left) or a dead compressor.

Offline mdm6713

  • VIP Member
  • Member Since: Jan 2009
  • Posts: 10
Re: GE 6 years old fridge not cooling, compressor on 24/7?
« Reply #2 on: January 13, 2009, 01:37:02 PM »
Thanks for your early reply...are you almost certain of that? Im not going to replace the compressor, Ill get a new ref. And Id like to save the headache and just move on at this point. I would like to fix it if I can though. Any popular places these things like to leak? Michael

Offline Mr. Fix-It

  • Technician
  • Member Since: Jan 2009
  • Posts: 357
Re: GE 6 years old fridge not cooling, compressor on 24/7?
« Reply #3 on: January 13, 2009, 01:42:19 PM »
You would need a tech to check it it's not a DIY job.

Offline mdm6713

  • VIP Member
  • Member Since: Jan 2009
  • Posts: 10
Re: GE 6 years old fridge not cooling, compressor on 24/7?
« Reply #4 on: January 13, 2009, 01:46:55 PM »
Im a tech..novice ;o) Its one omy my rental properties and Im a general contractor, I wont replace it..but I like to diagnose it all the way if I can. Im getting ready to take the inside out. Ive seen leaks on outdoor ac units...I want to check the internal parts too for anything obvious.
thanks again and any more suggestions I could really use I would appreciate it.
Michael

Offline Mr. Fix-It

  • Technician
  • Member Since: Jan 2009
  • Posts: 357
Re: GE 6 years old fridge not cooling, compressor on 24/7?
« Reply #5 on: January 13, 2009, 02:18:12 PM »
You need a special device called a leak detecter and other special tools that an HVAC tech would have not to mention the regs about handling refridgerant.

Offline jumptrout51

  • Technician
  • Member Since: Nov 2007
  • Posts: 1879
  • Country: us
    • Buy me a beer through paypal
Re: GE 6 years old fridge not cooling, compressor on 24/7?
« Reply #6 on: January 13, 2009, 02:28:16 PM »
Take a amp meter and attach it to a single wire at the wiring at the compressor relay. It should read about 2 amps if the compressor is running.
Touch the smaller of the 2 refrigerant lines on the compressor that go inside the fridge walls. The smaller line will be hot to the touch if refrigerant is there and circulating the system.
If the amp draw is good and the line is cool you have a leak in the refrigerant circuit.
If no amp draw a bad relay or bad compressor.
« Last Edit: January 13, 2009, 02:30:59 PM by jumptrout51 »
Take a Kid fishing.

Offline mdm6713

  • VIP Member
  • Member Since: Jan 2009
  • Posts: 10
Re: GE 6 years old fridge not cooling, compressor on 24/7?
« Reply #7 on: January 13, 2009, 02:44:06 PM »
Neither one of the lines is really carrying any heat...does it suggest anything?

Offline jumptrout51

  • Technician
  • Member Since: Nov 2007
  • Posts: 1879
  • Country: us
    • Buy me a beer through paypal
Re: GE 6 years old fridge not cooling, compressor on 24/7?
« Reply #8 on: January 13, 2009, 02:56:22 PM »
You have to verify the compressor is running.
If the compressor is running and no heat in the smaller line = no refrigerant.
Therefore, a leak.
Take a Kid fishing.

Offline mdm6713

  • VIP Member
  • Member Since: Jan 2009
  • Posts: 10
Re: GE 6 years old fridge not cooling, compressor on 24/7?
« Reply #9 on: January 13, 2009, 02:58:56 PM »
The compressor is on, slight vibration and hum...it was hot from running non stop, doesnt seem to shut off at all....any thing else come to mind? Im heading back there now.
thanks a lot guys
Michael

Offline mdm6713

  • VIP Member
  • Member Since: Jan 2009
  • Posts: 10
Re: GE 6 years old fridge not cooling, compressor on 24/7?
« Reply #10 on: January 13, 2009, 03:06:12 PM »
oh yea...anywhere they frequently leak?

Offline jumptrout51

  • Technician
  • Member Since: Nov 2007
  • Posts: 1879
  • Country: us
    • Buy me a beer through paypal
Re: GE 6 years old fridge not cooling, compressor on 24/7?
« Reply #11 on: January 13, 2009, 03:07:24 PM »
Look inside the freezer for a ice buildup on the back wall. No ice buildup, then you have a refrigerant leak or defective compressor not pumping.
« Last Edit: January 13, 2009, 03:10:18 PM by jumptrout51 »
Take a Kid fishing.

Offline mdm6713

  • VIP Member
  • Member Since: Jan 2009
  • Posts: 10
Re: GE 6 years old fridge not cooling, compressor on 24/7?
« Reply #12 on: January 13, 2009, 03:13:51 PM »
Sounds like scrap metal...aahhhh
thanks

Offline jumptrout51

  • Technician
  • Member Since: Nov 2007
  • Posts: 1879
  • Country: us
    • Buy me a beer through paypal
Re: GE 6 years old fridge not cooling, compressor on 24/7?
« Reply #13 on: January 13, 2009, 03:14:06 PM »
oh yea...anywhere they frequently leak?

Could be anywhere in the sealed system. You have to add refrigerant and check with a leak detector or flourescent dye.
Take a Kid fishing.

Offline JWWebster

  • Technician
  • Member Since: Jan 2008
  • Posts: 8780
  • Country: us
  • SublimeMasterJW
    • Buy me a beer through paypal
    • JW's Sublime Appliance Advice
Re: GE 6 years old fridge not cooling, compressor on 24/7?
« Reply #14 on: January 13, 2009, 10:36:59 PM »
Woe there Kimosabe. Don't poopecan that icebox just yet. What do yall mean this is a tech job? The man done replace the computer board is that a light bulb? Thankyou. Get you an A-1 tap and some gauges and check the level of freon. Add 4 ounces and see if she cools down The ice box uses R134a and ANYBODY can buy it, it is deemed safe to the atmosphere. Use an old school halide torch to search  for leaks. Let me know if you find one and I will tell yas how to deal with it. Hay if you have one bad icebox you gonna have a dozen. You might as well learn the ropes now Hoss.
« Last Edit: January 13, 2009, 10:41:31 PM by JWWebster »
May the hinges of our friendship
        never grow rusty.

About the icons: The beer is tip link, if a tech saves ya some money buy em a 6 pack. The small green square=personal message. The green dot is a link to my web page on appliance repair and other general BS I love to post. The letter sends me email.
I love fan letters! LOL

 

RFA17WCE Wood's frost free all fridge not cooling

Started by Ryan

Replies: 2
Views: 5064
Last post May 14, 2008, 10:10:10 PM
by JWWebster
CROSLEY FRIDGE FREEZER NOT COOLING

Started by flair

Replies: 9
Views: 7871
Last post October 15, 2009, 08:02:50 PM
by JWWebster
Kenmore/Whirpool fridge cooling problems

Started by woozy_one

Replies: 20
Views: 13729
Last post June 02, 2011, 08:35:17 PM
by woozy_one
FRS26ZNH fridge not cooling, freezer at about 44 degrees

Started by freeflown

Replies: 1
Views: 3544
Last post June 02, 2009, 09:59:48 PM
by BrntToast
Whirlpool fridge compressor

Started by jvh75021

Replies: 5
Views: 4093
Last post November 20, 2009, 10:21:49 AM
by JWWebster
jenair fridge not cooling

Started by pallanesfour

Replies: 2
Views: 1842
Last post December 02, 2009, 10:58:48 AM
by pallanesfour