Author Topic: Frigidaire Commercial Display cooler  (Read 5470 times)

Offline jumptrout51

  • Technician
  • Member Since: Nov 2007
  • Posts: 1879
  • Country: us
    • Buy me a beer through paypal
Frigidaire Commercial Display cooler
« on: October 05, 2008, 05:20:16 PM »
Commercial display cooler. Glass front, double door on back.
Model BRD 60 SF.
Anyone have a wiring diagram?
Take a Kid fishing.

Offline Repair-man

  • Technician
  • Member Since: Feb 2008
  • Posts: 3020
  • Country: us
  • The Virtual Repairman
    • The Virtual Repairmans Appliance Help
Re: Frigidaire Commercial Display cooler
« Reply #1 on: October 05, 2008, 07:31:10 PM »
I might can help you with a specific problem. What is the unit doing?

 The diagram is sometimes inside the console.

Console Removal
« Last Edit: October 05, 2008, 07:33:58 PM by Repair-man »
"It's only expensive if someone else fixes it for you" -
The Virtual Repairman   www.repair2000.com

Offline jumptrout51

  • Technician
  • Member Since: Nov 2007
  • Posts: 1879
  • Country: us
    • Buy me a beer through paypal
Re: Frigidaire Commercial Display cooler
« Reply #2 on: October 05, 2008, 07:58:08 PM »
The cover to the control box is missing. It was probably glued to that cover. Another technician pronounced the compressor dead. He was right.
I have been asked to replace the compressor. The discharge line has a solenoid valve on it . I presume a pump down valve. It has no wires going to it. I need to find out where the valve wires connect inside the control panel.
Take a Kid fishing.

Offline JWWebster

  • Technician
  • Member Since: Jan 2008
  • Posts: 8781
  • Country: us
  • SublimeMasterJW
    • Buy me a beer through paypal
    • JW's Sublime Appliance Advice
Re: Frigidaire Commercial Display cooler
« Reply #3 on: October 05, 2008, 08:10:20 PM »
that solenoid valve has go to do with defrost right?
May the hinges of our friendship
        never grow rusty.

About the icons: The beer is tip link, if a tech saves ya some money buy em a 6 pack. The small green square=personal message. The green dot is a link to my web page on appliance repair and other general BS I love to post. The letter sends me email.
I love fan letters! LOL

Offline Repair-man

  • Technician
  • Member Since: Feb 2008
  • Posts: 3020
  • Country: us
  • The Virtual Repairman
    • The Virtual Repairmans Appliance Help
Re: Frigidaire Commercial Display cooler
« Reply #4 on: October 05, 2008, 09:31:14 PM »
Quote
I have been asked to replace the compressor.

So, refuse to do so without the proper documents or at least do so with the understanding that no warranty is provided with the repair..


The solenoid is the hot gas defrost for this unit.  If this is the case, it is controlled by the defrost timer or any thermisters which may be in there. If you are jumping into a unit which has a questionable history...get out now...

Without the  documents for this unit you are fumbling in the dark. Obviously something has been extensively repaired on this unit already for the solenoid to not be connected and a bad compressor to boot.
« Last Edit: October 06, 2008, 06:05:17 AM by Repair-man »
"It's only expensive if someone else fixes it for you" -
The Virtual Repairman   www.repair2000.com

Offline RegUS_PatOff

  • Technician
  • Member Since: Dec 2007
  • Posts: 1410
  • Country: us
Re: Frigidaire Commercial Display cooler
« Reply #5 on: October 06, 2008, 06:12:29 AM »
are your sure of the model number ?
After leaving this Earth, "Do you want the smoking or non-smoking section?"

Offline jumptrout51

  • Technician
  • Member Since: Nov 2007
  • Posts: 1879
  • Country: us
    • Buy me a beer through paypal
Re: Frigidaire Commercial Display cooler
« Reply #6 on: October 06, 2008, 07:47:37 AM »
JW..yes, I am certain it has to do with defrost. Everything appears to be hot gas defrost.

Repair-man..I believe I only need to connect it to a normally open contact on the timer. This unit has the original compressor and a full refrigerant charge. It is a semi-hermetic unit. I believe a bad valve plate. It runs but does not pump.

RegUs...That is the only model number on the sticker. Manufactured by Frigidaire Commercial Products.
Take a Kid fishing.

Offline Repair-man

  • Technician
  • Member Since: Feb 2008
  • Posts: 3020
  • Country: us
  • The Virtual Repairman
    • The Virtual Repairmans Appliance Help
Re: Frigidaire Commercial Display cooler
« Reply #7 on: October 06, 2008, 08:50:17 AM »
Quote
I believe I only need to connect it to a normally open contact on the timer.  I believe a bad valve plate. It runs but does not pump.

I agree on both counts.

I'd connect the coil to a neutral on one side and the  n/o contact on the defrost control. Test the coil in place with a 120v cord to ensure the  valve works.
« Last Edit: October 06, 2008, 08:52:26 AM by Repair-man »
"It's only expensive if someone else fixes it for you" -
The Virtual Repairman   www.repair2000.com

Offline Icehouse

  • Technician
  • Member Since: Oct 2008
  • Posts: 569
    • hvacbob
Re: Frigidaire Commercial Display cooler
« Reply #8 on: October 23, 2008, 09:21:13 PM »
Fridgidaire Commercial has been taken over by Carrier.
I will look in the morning. Have a lot of downloads from them.
NATE, NCCER, PHCC,HVAC Certified Instructor
Member RSES, US Army Refrigeration Specialist(Retired), Former Refrigeration Teacher NYC Board of Ed.
a tragedy has happen to me : http://web.me.com/zenzoidman/Bobice/

Offline Icehouse

  • Technician
  • Member Since: Oct 2008
  • Posts: 569
    • hvacbob
NATE, NCCER, PHCC,HVAC Certified Instructor
Member RSES, US Army Refrigeration Specialist(Retired), Former Refrigeration Teacher NYC Board of Ed.
a tragedy has happen to me : http://web.me.com/zenzoidman/Bobice/

Offline jumptrout51

  • Technician
  • Member Since: Nov 2007
  • Posts: 1879
  • Country: us
    • Buy me a beer through paypal
Re: Frigidaire Commercial Display cooler
« Reply #10 on: December 07, 2008, 09:45:00 AM »
**UPDATE**

I did the compressor changeout on this box.
It has been running fine for 60 days now.
Take a Kid fishing.

Offline AJ

  • Technician
    Administrator
  • Member Since: Jun 2007
  • Posts: 9478
  • Country: us
    • ApplianceJunk.com - Appliance Repair
Re: Frigidaire Commercial Display cooler
« Reply #11 on: December 07, 2008, 09:50:40 AM »
Glad to hear it's working.
Thanks for the update.  O0
Hope you find our site helpful.

Offline acarson

  • VIP Member
  • Member Since: Jun 2011
  • Posts: 1
Re: Frigidaire Commercial Display cooler
« Reply #12 on: June 09, 2011, 03:54:29 PM »
Model BRD-60SF
Does anyone have an owner/operator manual, picture of serial tag, spec sheet Anything on this unit?

Offline jumptrout51

  • Technician
  • Member Since: Nov 2007
  • Posts: 1879
  • Country: us
    • Buy me a beer through paypal
Re: Frigidaire Commercial Display cooler
« Reply #13 on: June 09, 2011, 05:10:16 PM »
I do not,but 2 and 1/2 years later this unit is still working fine.
What is your problem?
Take a Kid fishing.

 

Frigidaire Refrig Model LGUB2642L Display code SY CF

Started by smay

Replies: 1
Views: 1542
Last post July 09, 2014, 03:04:54 PM
by VOGUSLAVKY
Frigidaire water actuator replacement

Started by hon2007

Replies: 4
Views: 10703
Last post November 24, 2007, 07:26:23 PM
by AJ
5995436457 Frigidaire Ice Maker Service Manual

Started by apptech

Replies: 0
Views: 2426
Last post March 17, 2008, 06:36:32 PM
by apptech
Frigidaire Refrigerator Ice Dispenser Problems

Started by TechnicianBrian

Replies: 2
Views: 7686
Last post June 11, 2013, 01:23:14 PM
by kcfinch
Frigidaire Refrigerator not cooling anymore :(?

Started by yahoo

Replies: 4
Views: 7274
Last post March 29, 2008, 08:19:36 AM
by JWWebster
Frigidaire Refrigerator Won't Make Ice

Started by TechnicianBrian

Replies: 0
Views: 4593
Last post April 09, 2008, 07:35:03 PM
by TechnicianBrian