Author Topic: GE Dishwasher Washes with the Door Open  (Read 1671 times)

Offline TechnicianBrian

  • Technician
  • Member Since: Dec 2007
  • Posts: 390
  • Country: us
    • TechnicianBrian.com
GE Dishwasher Washes with the Door Open
« on: September 26, 2008, 06:29:28 AM »

Model #ZBD710501GSSicon, this dishwasher, while seeming to operate and wash OK, will not stop washing when the door is opened. The customer wasn't sure when this odd behavior began since most loads are started and the door isn't opened until the end of the cycle. But one day while trying to add a dish during a wash cycle that had just been started, the door was opened and water went everywhere. Knowing that wasn't correct, it was time for service.



Dishwasher door latches will have one or more interlock switches that are used for the purpose of cutting power, and/or informing the control board when the door has been opened. These can be wired in series with the wash pump or other load components preventing current flow when the door is opened. Or as in this model, can be used as a monitor circuit to tell the control board the position of the door latch.

When the door on this model is opened, the interlock switch contacts will close completing the monitor circuit back to the control board. Continuity through the circuit tells the electronics the door is open and to stop operating. When the door is closed, the switch contacts will open, thus opening the monitor circuit which the electronics will interpret as the door being closed.

The interlock switch on this unit was operating properly which leaves the control board as being the component that has failed. Mechanical switches, like the one mounted in the latch assemblyicon are more likely to fail, but on this unit, the control board was the problem. Installed a new control boardicon assembly and now the dishwasher stops washing when the door is opened.

 

Amana dishwasher- door hard to open- not opening at all

Started by leish19

Replies: 2
Views: 7178
Last post July 28, 2008, 08:12:57 PM
by whirlpooltech
I have a Bosch dishwasher and the detergent door does not open during the wash

Started by dpbrasil

Replies: 4
Views: 2398
Last post July 27, 2009, 09:07:41 PM
by JWWebster
Aeg Dishwasher door comes open.

Started by Franco99

Replies: 2
Views: 1622
Last post September 26, 2009, 11:46:15 AM
by Franco99
Dishwasher detergent door does not open

Started by cndesu

Replies: 1
Views: 1311
Last post January 16, 2010, 09:02:23 AM
by jumptrout51
Kitchen Aid Dishwasher Door pops open

Started by krazytech

Replies: 3
Views: 2834
Last post July 14, 2011, 06:27:30 PM
by sc
dishwasher runs with door open

Started by Jen

Replies: 5
Views: 1215
Last post July 22, 2012, 08:34:44 AM
by haroldsappliance