Author Topic: Whirlpool Dishwasher Noise during Wash  (Read 6654 times)

Offline TechnicianBrian

  • Technician
  • Member Since: Dec 2007
  • Posts: 390
  • Country: us
    • TechnicianBrian.com
Whirlpool Dishwasher Noise during Wash
« on: September 02, 2008, 07:31:25 AM »

Model #GU2500XTPQ6, this tall tub dishwasher began making a noise while washing that became progressively worse over time. Because the unit was still functioning properly, there seemed no immediate reason for a service call, but eventually, the noise of the unit won out, and I was called in for the repair.



Dishwashers use a motor and shaft mounted impeller to recirculate water throughout the tub during a wash cycle and depending on make and model, may also be used during the drain cycle to remove the dirty water. The motor and impeller comprise the pump portion of the unit and will be be mounted vertically or horizontally to a sump located under the tub. Rotating at high RPM's, these pumps can move small amounts of water under fairly high pressures during a typical wash, resulting in clean dishes at the end of the cycle.


Many dishwashers use screens to filter the recirculated water to protect the impeller and motor from damage caused by large food particles or foreign objects that find their way into the dishwasher. Others, like this model, will use a chopper blade (see below) to help break down organic material into small particles for easy removal from the sump during the drain cycle. These screes are often the source for high pitches noises that last for seconds to several minutes as the impeller or chopper work to grind down this material until it is able to pass through the screen and out with the waste water.



Unfortunately, if the noise doesn't fade after a brief period, or continues to get worse, the most likely reason is something stuck that cannot be reduced to pass out of the sump. Or worse (more expensive), something hard that contacted the high speed impeller resulting in permanent damage to the motor shaft. Which, by the way, is what was causing the noise on this unit. Even with the motor removed from the sump assembly, the noise continued so I knew it was time to be replaced.


The sump and pump assembly on the Whirlpool products is very easy to service without the need to pull the dishwasher out from under the counter and is often replaced as a complete pump and motor assembly. But this customer was on a tighter budget and after looking over the rest of the sump, I determined only the washer motor itself needed replacement. Removed the sump, installed a new motor, and now this dishwasher is as quiet as it has ever been.


It is important to remember that routine cleaning of filter screens and chopper assemblies along with proper scrapping of dishes prior to washing can go a long way toward preventing this kind of service call.


If you would like to receive updates of new articles, information and news, be sure to subscribe to the Appliance Repair & Training Blog feed!

 

Ultra Wash Dishwasher Noise

Started by ronbeld

Replies: 0
Views: 1875
Last post December 31, 2008, 02:56:30 PM
by ronbeld
675806 Whirlpool Dishwasher Drain & Wash Impeller Kit

Started by AJ

Replies: 0
Views: 3957
Last post April 07, 2009, 03:25:45 PM
by AJ
Whirlpool dishwasher making buzzing noise

Started by Ally

Replies: 0
Views: 2952
Last post April 22, 2011, 08:27:41 PM
by Ally
Whirlpool Dishwasher - No wash at all - Goes to drain immediately then "clean"

Started by geohec

Replies: 6
Views: 3433
Last post August 27, 2011, 09:26:19 AM
by geohec
whirlpool DU1030XTXS1 dishwasher stops running after first wash cycle

Started by Lanelle

Replies: 1
Views: 1550
Last post August 01, 2012, 07:45:33 AM
by AJ
Whirlpool Dishwasher GU1200XTLQ1 Dead, clean light blinks.

Started by barb

Replies: 2
Views: 6219
Last post August 11, 2007, 08:05:47 AM
by barb