Author Topic: Whirlpool Gold Making Ice Very, Very Slowly...  (Read 2709 times)

Offline Msufinprof

  • VIP Member
  • Member Since: Mar 2013
  • Posts: 2
  • Country: us
Whirlpool Gold Making Ice Very, Very Slowly...
« on: March 23, 2013, 11:37:50 AM »
Our Whirlpool Gold SxS ice maker is making ice very, very...did I say very... slowly.  Also, the infrared sensor is blinking twice with a one second delay whether the line of sight for the light is blocked or the flapper door is held in and is clear...still blinking twice.

Any ideas on if I need to replace the light and sensor.  There is little to no ice in the tub and it will make two or three trays of ice per 24 hour period.  I have taken the ice tub out and made sure it is defrosted, taken the light and sensor on each side out and looked them over.  The teeth are in the two o'clock position.  What is my next move?

Thanks so much for any help.

Steve

Offline domain

  • Technician
  • Member Since: Nov 2012
  • Posts: 1078
  • Country: us
Re: Whirlpool Gold Making Ice Very, Very Slowly...
« Reply #1 on: March 23, 2013, 02:16:11 PM »
Could be quite a few things, actually. I am no pro with optic boards so I wont go there. What I do on any no/slow ice call is take temp of ice room/area FIRST . NOT with an infrared gun. I use a K type thermocouple attached to my fluke. Usually below 10 degrees or so is what I want. Two things after that, Bi metal in the ice mold or low water pressure. Then the optics which I know zero about.... O0
« Last Edit: March 23, 2013, 02:17:11 PM by domain »

Offline JWWebster

  • Technician
  • Member Since: Jan 2008
  • Posts: 8781
  • Country: us
  • SublimeMasterJW
    • Buy me a beer through paypal
    • JW's Sublime Appliance Advice
Re: Whirlpool Gold Making Ice Very, Very Slowly...
« Reply #2 on: March 23, 2013, 02:54:36 PM »
Clean up the cobwebs from beneath the ice box
May the hinges of our friendship
        never grow rusty.

About the icons: The beer is tip link, if a tech saves ya some money buy em a 6 pack. The small green square=personal message. The green dot is a link to my web page on appliance repair and other general BS I love to post. The letter sends me email.
I love fan letters! LOL

Offline Patricio

  • Technician
  • Member Since: Aug 2011
  • Posts: 406
  • Country: us
  • Tight Lines
Re: Whirlpool Gold Making Ice Very, Very Slowly...
« Reply #3 on: March 23, 2013, 07:59:19 PM »
Tape the door latch down 7 hold the flapper back.  unplug refer for a minute & plug back in.  unit should begin harvest cycle.  Check that fingers cycle, heater heats 7 water fills.  if does not cycle more than likly ya need to replace optics.   Can't remenber which pins to short out to make it work from the receiver side.    Had one where the optics ailed, no light 7 the thing just made ice.  evertime lady would open door ice flooded her kitchen.    I to go with my lady, will try to get you some info.
Great Old Fashion Hometown Service

Offline Patricio

  • Technician
  • Member Since: Aug 2011
  • Posts: 406
  • Country: us
  • Tight Lines
Re: Whirlpool Gold Making Ice Very, Very Slowly...
« Reply #4 on: March 23, 2013, 08:07:31 PM »
Go to you tube, type ' optical icemaker' in search bar.  several flicks on this type of control.   The optics are just a complicated switch that tells the IM whether the bucket is full or not.   most of the units with optics, the door switch has to be closed for it to work, switch is in series
Great Old Fashion Hometown Service

Online dab147315

  • Technician
  • Member Since: Oct 2010
  • Posts: 1665
  • Country: us
Re: Whirlpool Gold Making Ice Very, Very Slowly...
« Reply #5 on: March 23, 2013, 09:33:33 PM »
To jump out optics read this .But you could have ice maker the most common problem.Plug up fill tube. Or bad water valve.Manual put water in ice maker if none is there to see if makes cubes.How is the rest of the food in freezer its it all frozen.Ice cream frozen is a good indicator that the freezer temperature is ok.

Online dab147315

  • Technician
  • Member Since: Oct 2010
  • Posts: 1665
  • Country: us
Re: Whirlpool Gold Making Ice Very, Very Slowly...
« Reply #6 on: March 23, 2013, 09:36:02 PM »
Read this.

Online dab147315

  • Technician
  • Member Since: Oct 2010
  • Posts: 1665
  • Country: us
Re: Whirlpool Gold Making Ice Very, Very Slowly...
« Reply #7 on: March 23, 2013, 10:04:05 PM »
Good luck.

Offline Bailey

  • Technician
  • Member Since: Dec 2011
  • Posts: 663
  • Country: us
Re: Whirlpool Gold Making Ice Very, Very Slowly...
« Reply #8 on: March 23, 2013, 11:51:40 PM »
The freezer temp should be around zero. The closer to 15 degrees, the slower the ice production. Above 15 it may not make ice at all.

Offline Msufinprof

  • VIP Member
  • Member Since: Mar 2013
  • Posts: 2
  • Country: us
Re: Whirlpool Gold Making Ice Very, Very Slowly...
« Reply #9 on: March 24, 2013, 12:04:32 AM »
Thanks for all the ideas.  In terms if temp there have been no problems with other items being frozen solid.  The odd thing is that it will dump a tray of ice and then go for a long while before dumping another.  The ice compartment never even starts to get full.  We just moved in to this house about three weeks ago so don't have a long history with this unit.

 

Whirlpool Gold Ice Maker not working- please help

Started by pudge2824

Replies: 6
Views: 34888
Last post March 04, 2008, 10:00:39 PM
by JWWebster
Whirlpool Refrigerator not making Ice

Started by TechnicianBrian

Replies: 0
Views: 2470
Last post June 09, 2008, 08:17:34 PM
by TechnicianBrian
Whirlpool Gold Ice Not Ejecting

Started by Texanite

Replies: 2
Views: 2635
Last post January 18, 2009, 11:39:21 AM
by JWWebster
whilrpool Fridge whirlpool gold

Started by scubastieb

Replies: 2
Views: 2207
Last post April 02, 2009, 11:26:20 AM
by scubastieb
Whirlpool Gold S/S bad air flow to refer

Started by Mmfh

Replies: 3
Views: 2073
Last post December 29, 2009, 05:33:43 PM
by Mmfh
Whirlpool Gold 51 lb Ice Maker Stopped Working

Started by ugalisa

Replies: 1
Views: 2746
Last post April 27, 2010, 04:41:44 PM
by jumptrout51