Author Topic: Testing Timers  (Read 779 times)

Offline blondejon

  • Technician
  • Member Since: Jun 2011
  • Posts: 199
    • RenewAppliance
Testing Timers
« on: September 11, 2012, 09:36:03 PM »
Is there any way to test a timer without having the machine present?  Or if you do have the machine present, what's the quickest way to test the timer so that you don't have to wait for the washer/dryer to go through all the cycles?

Thanks

Offline Bailey

  • Technician
  • Member Since: Dec 2011
  • Posts: 625
  • Country: us
Re: Testing Timers
« Reply #1 on: September 12, 2012, 01:15:39 PM »
It is hard to test a timer off the machine.Usually you are looking for a specific problem such as no spin. You would need the wiring diagram to tell you which contacts would be closed but without the dial and faceplate you wouldn't know where the spin cycle was. Also on these modern timers the wires plug into the timer in a single block so you have no way to know which color of wire goes where. I miss the old style of timers like on a Maytag. Even though there may be 20 wires to change from one timer to the next, the timer was stamped with the color of wire that was supposed to go there.

Offline blondejon

  • Technician
  • Member Since: Jun 2011
  • Posts: 199
    • RenewAppliance
Re: Testing Timers
« Reply #2 on: September 15, 2012, 11:24:28 AM »
Thanks for the reply and the very good points.  I was hoping for a somewhat magical trick that maybe some of you veterans were aware of.   O0

Offline RegUS_PatOff

  • Technician
  • Member Since: Dec 2007
  • Posts: 1410
  • Country: us
Re: Testing Timers
« Reply #3 on: September 15, 2012, 08:58:23 PM »
on some Timers, you can take a look inside at the Contacts ..
After leaving this Earth, "Do you want the smoking or non-smoking section?"

donate
$1, $2, $5, $10, $20, $50
 

fex831cs0 measuring voltage drop when testing for defective part

Started by viking351

Replies: 1
Views: 1331
Last post February 01, 2009, 05:39:02 AM
by Icehouse
Intermatic Recalls Digital Timers Due to Shock Hazard

Started by AJ

Replies: 0
Views: 1272
Last post February 05, 2009, 10:39:58 AM
by AJ
Mommy bloggers testing out Frigidaire appliances.

Started by AJ

Replies: 0
Views: 1244
Last post June 03, 2009, 01:50:01 PM
by AJ
Motor Testing

Started by magician59

Replies: 8
Views: 2641
Last post February 26, 2010, 06:08:10 PM
by JWWebster