Author Topic: LG W/D Combo leaves clothes wet  (Read 5468 times)

Offline wildimaginations

  • Technician
  • Member Since: Jul 2011
  • Posts: 621
  • Country: us
Re: LG W/D Combo leaves clothes wet
« Reply #20 on: June 15, 2012, 10:28:02 PM »
The red led light on the motherboard means that there is power to the board.  Nothing is wrong with the board.

You say that the clothes are still wet and it is hot at the end of the cycle.  I had the same problem with another LG unit and this is what I found.  The drain hose in back was too long.  What I mean is the drain line looped down to nearly the bottom of the washer and then back up to the drain line.  On these washer dryer combos, during the drying cycle, the drain pump will only cycle on for 1 second and then off for 2 minutes.  Because of this, the drain pump cannot get the water out of the washer drum properly.  You will need to get behind the washer and stuff the drain hose into the drain pipe more to shorten the loop to allow the drain pump to work properly.  At least get the bottom of the loop up around half way up the back of the washer.

Be sure to check the drain filter to make sure it's clean.

Hope this helps. 
Appliance Service Technician
Authorized servicer on LG appliances.
About 45 mins east of San Francisco

Offline clman

  • Technician
  • Member Since: May 2012
  • Posts: 68
  • Country: us
  • 25 Years Appliance and Air Conditioning experience
    • Buy me a beer through paypal
Re: LG W/D Combo leaves clothes wet
« Reply #21 on: June 16, 2012, 10:39:21 PM »
Dirty voltage, a somewhat faulty part in the machine, environmental issues and crappy manufacturing could all be causing multiple pcb failures. Oh and really bad luck to.

Offline Los

  • VIP Member
  • Member Since: Jun 2012
  • Posts: 14
Re: LG W/D Combo leaves clothes wet
« Reply #22 on: July 09, 2012, 11:46:13 AM »
I discovered the problem.  My machine has a four valve inlet assembly, AppliancePartsPros sent me a motherboard for a three valve inlet.  So the fourth valve, the dryer inlet valve, has been letting water into the dry cycle.

Thank You all for your responses and assistance - it is much appreciated!

Offline clman

  • Technician
  • Member Since: May 2012
  • Posts: 68
  • Country: us
  • 25 Years Appliance and Air Conditioning experience
    • Buy me a beer through paypal
Re: LG W/D Combo leaves clothes wet
« Reply #23 on: July 09, 2012, 11:52:04 AM »
There's one for the books.

Offline AJ

  • Technician
    Administrator
  • Member Since: Jun 2007
  • Posts: 9607
  • Country: us
    • ApplianceJunk.com - Appliance Repair
Re: LG W/D Combo leaves clothes wet
« Reply #24 on: July 09, 2012, 11:59:45 AM »

Hi Los,


Glad you found the problem, thanks for the update.  O0


I'm not sure just what part you are talking about. Could you post the part number for us?


Thanks,
Hope you find our website helpful.

Offline Los

  • VIP Member
  • Member Since: Jun 2012
  • Posts: 14
Re: LG W/D Combo leaves clothes wet
« Reply #25 on: July 09, 2012, 01:00:51 PM »
[AP4441934] which is a 4 valve cold water valve.  see pic.  APP is saying they sent me the right board for it.  However, the dryer valve is opening and closing during drying allowing water into the machine thereby wetting my clothes.  What is the purpose of this dryer inlet valve?  Why would you want water into your dryer side?  I think I will try to run the machine with just this valve disconnected...

Offline JWWebster

  • Technician
  • Member Since: Jan 2008
  • Posts: 8781
  • Country: us
  • SublimeMasterJW
    • Buy me a beer through paypal
    • JW's Sublime Appliance Advice
Re: LG W/D Combo leaves clothes wet
« Reply #26 on: July 09, 2012, 03:47:06 PM »
Probably has to do with steam like when you used to iron clothes you kept a coke bottle full of water to sprinkle on them to help steam the wrinkles out. Who know? LOL
May the hinges of our friendship
        never grow rusty.

About the icons: The beer is tip link, if a tech saves ya some money buy em a 6 pack. The small green square=personal message. The green dot is a link to my web page on appliance repair and other general BS I love to post. The letter sends me email.
I love fan letters! LOL

Offline haroldsappliance

  • Technician
  • Member Since: Nov 2011
  • Posts: 616
  • Country: us
    • Appliance repair
Re: LG W/D Combo leaves clothes wet
« Reply #27 on: July 09, 2012, 05:35:08 PM »
Always go outside and verify proper air flow.

Online tgoods

  • Technician
    Moderator
  • Member Since: Jul 2010
  • Posts: 1527
  • Country: us
    • Buy me a beer through paypal
Re: LG W/D Combo leaves clothes wet
« Reply #28 on: July 09, 2012, 09:03:18 PM »
A ventless dryer needs to condense the steam into water and then pump the water out.  The cold water sprays into the condenser.  If your drain pump is working, it should never touch the clothes during the dry cycle.

Offline Los

  • VIP Member
  • Member Since: Jun 2012
  • Posts: 14
Re: LG W/D Combo leaves clothes wet
« Reply #29 on: July 17, 2012, 12:30:20 PM »
The dryer valve is for letting water into the dry cycle for steaming the clothes to prevent wrinkles - works best with fewer clothes.  If this valve is malfunctioning and allowing too much water in, then clothes never dries only gets wetter. 

This unit is does not vent to the outside.

Drain pump was not the issue has -  new drain pump.

Thanks

 

LG Leaves clothes damp

Started by Rick32k

Replies: 19
Views: 3296
Last post April 09, 2013, 04:51:42 PM
by desert
amana clothes dryer LEA50AW

Started by jmsrnsn

Replies: 1
Views: 2840
Last post December 17, 2007, 06:05:49 PM
by AJ
Whirlpool Dryer won't keep running after door opened when clothes are dry

Started by Nancy

Replies: 4
Views: 3256
Last post February 10, 2008, 12:32:34 PM
by JWWebster
Simpson Maxi Dry 505 (reverse cycle clothes dryer)

Started by laudesan

Replies: 6
Views: 4041
Last post April 26, 2008, 06:36:15 PM
by laudesan
Frigidaire Dryer Tearing Clothes

Started by TechnicianBrian

Replies: 0
Views: 4027
Last post June 06, 2008, 01:58:24 PM
by TechnicianBrian
Dryer ruins clothes!

Started by hurlburt

Replies: 3
Views: 3367
Last post September 28, 2008, 02:45:54 PM
by JWWebster